Regular Article
Environmental controls in operating theatres

https://doi.org/10.1053/jhin.2002.1217Get rights and content

Abstract

Surgical-site infection is the leading complication of surgery. Normal skin flora of patients or healthcare workers causes more than half all infections following clean surgery, but the importance of airborne bacteria in this setting remains controversial. Modern operating theatres have conventional plenum ventilation with filtered air where particles ≥5 μm are removed. For orthopaedic and other implant surgery, laminar-flow systems are used with high-efficiency particulate air (HEPA) filters where particles ≥0.3 μm are removed. The use of ultra-clean air has been shown to reduce infection rates significantly in orthopaedic implant surgery. Few countries have set bacterial threshold limits for conventionally ventilated operating rooms, although most recommend 20 air changes per hour to obtain 50–150 colony forming units/m3 of air. There are no standardized methods for bacterial air sampling or its frequency. With the use of HEPA filters in operating theatre ventilation, there is a tendency to apply cleanroom technology standards used in industry for hospitals. These are based on measuring the presence of particles of varying sizes and numbers, and are better suited than bacterial sampling. Environmental bacterial sampling in operating theatres should be limited to investigation of epidemics, validation of protocols, or changes made in materials which could influence the microbial content.

References (38)

  • W Whyte et al.

    Suggested bacteriological standards for air in ultraclean operating rooms

    J Hosp Infect

    (1983)
  • B Friberg et al.

    Inconsistent correlation between aerobic bacterial surface and air counts in operating rooms with ultra clean laminar air-flows: proposal of a new bacteriological standard for surface contamination

    J Hosp Infect

    (1999)
  • C Pasquarella et al.

    The index of microbial air contamination

    J Hosp Infect

    (2000)
  • GAJ Ayliffe

    Role of the environment of the operating suite in surgical wound infection

    Rev Infect Dis

    (1991)
  • J Charnley et al.

    Postoperative infection in total prosthetic replacement arthroplasty of hip joint

    Br J Surg

    (1969)
  • OM Lidwell et al.

    The effect of ultraclean air in operating rooms on deep sepsis in the joint after hip or knee replacement: a randomised study

    Br Med J

    (1982)
  • H Laufman

    Airflow effects in surgery

    Arch Surg

    (1979)
  • A Schwan et al.

    Airborne contamination and post operative infection after total hip replacement

    Acta Orthop Scand

    (1977)
  • H Vasey et al.

    Zones protégées en salle d'opération. Evaluation d'une nouvelle enceinte de Charnley

    Med Hyg

    (1987)
  • Cited by (0)

    f1

    Author for correspondence: Professor Didier Pittet, Infection Control Programme, Department of Internal Medicine, University of Geneva Hospitals, 1211 Geneva 14, Switzerland; Tel. (office): +41-22/372 98 28; Fax: +41-22/372 39 87. E-mail:[email protected]

    View full text